Crossfield demonstrated his flight test skills on his very first student solo. His instructor was not available on the designated early morning, so Crossfield, on his own, took off and went through maneuvers he had practiced with his instructor, including spin entry and spin recovery. During the first spin, Crossfield experienced vibrations, banging, and noise in the aircraft that he had never encountered with his instructor. He recovered, climbed to a higher altitude, and repeated his spin entry and spin recovery, getting the same vibration, banging and noise. On his third spin entry, at yet an even higher altitude, he looked over his shoulder as he was spinning and observed the instructor’s door disengaged and flapping in the spin. He reached back, pulled the door closed, and discovered all the vibrations, banging and noise stopped. Satisfied, he recovered from the spin, landed, and fueled the airplane. He also realized his instructor had been holding the door during their practice spin entries and recoveries, and never mentioned this door quirk. In later years, Crossfield often cited his curiosity about this solo spin anomaly and his desire to analyze what was going on and why it happened, as the start of his test pilot career.
Shortly after launch on his third flight, one of these engines exploded. Unable to jettison his propellants, Crossfield was forced to make an emergency landing during which the excessive load on the aircraft broke its back just behind the cockpit. He was uninjured and the airplane was repaired.
On June 8, 1960, he had another close call during ground tests with the XLR-99 engine. He was seated in the cockpit of the No. 3 X-15 when a malfunctioning valve caused a catastrophic explosion. Once again he was uninjured as Dr. Toby Freedman, NAA Medical Director, pried open the cockpit to save him and despite being subjected to a later calculated acceleration force of near 50 Gs (although Crossfield stated in the Discovery Channel’s series Frontiers of Flight that he began to have debilitating issues with his night vision after the accident) and the airplane was completely rebu
Leave a Reply